Pipeline Anchor Strike May Have Occurred Months Before California Oil Spill

Estimates vary wildly when it comes to how much oil leaked from an undersea pipe and into the Pacific Ocean off the Orange County coast.

NBCUniversal Media, LLC

Coast Guard investigators say an underwater Southern California oil pipeline was likely struck by an anchor several months to a year before a major leak spilled tens of thousands of gallons of crude.

The U.S. Coast Guard says Friday that a large ship may have snagged the massive pipeline off Huntington Beach, but that might not have actually fractured the pipe.

Capt. Jason Neubauer says other ships may have struck the pipe later, which was dragged along the sea floor and spewed oil last weekend from a slender crack.

At least 17 accidents on pipelines carrying crude oil or other hazardous liquids have been linked to anchor strikes or suspected anchor strikes since 1986, according to an Associated Press review of more than 10,000 reports submitted to federal regulators.

Investigators in Southern California on Friday continued to hunt for the cause of a pipeline break about 5 miles off the coast that fouled beaches and killed seabirds. So far, they suspect a ship anchor snagged the pipeline and dragged it along the seabed, resulting in a 13-inch crack.

Two videos released so far hint at what happened below the surface, but the pipe showed no evidence of damage that experts said would be expected from a collision with a multi-ton anchor from cargo ships that routinely move through the area off the ports of Los Angeles and Long Beach.

Worries over local business, the environment, and more continue as the cleanup continues in Huntington Beach. Patrick Healy reports Oct. 6, 2021.

According to federal records, in some cases an anchor strike is never conclusively proven, such as 2012 leak from an ExxonMobil pipeline in Louisiana’s shallow Barataria Bay, where a direct strike by a barge or other boat also were considered possibilities.

In others the evidence of an anchor strike was obvious. During 1992’s Hurricane Andrew, a 30,000-pound anchor was dragged by a drifting drilling rig over a Texaco pipeline in the Gulf of Mexico, causing a dent that broke open when the line was later re-started.

In 2003, a 7,000 pound anchor was found about 10 feet from a small spill on a Shell Oil pipeline in the Gulf.

A Coast Guard video released Thursday appears to show a trench in the sandy seafloor leading to a bend in the submerged line, but experts offered varied opinions of the significance of the brief, grainy shots. An earlier video showcased a thin, 13-inch (33-centimeter) long rupture in the line.

Robert Bea, an engineering professor at the University of California, Berkeley and former Shell Oil engineer, said the second video appears to show a furrow in the seabed created by a dragging anchor leading to the damaged pipeline, which investigators have said was pulled across the ocean floor as much as 105 feet (32 meters).

Investigators, however, are expected to consider other forces that could have moved and damaged the pipe, including water currents of movement in the seabed.

It will take time.

“The results from the analyses need to be validated — corroborated. This process can bring even more questions,” Bea said. "The shape of the crack indicates that it was caused by internal pressures in the pipeline. But, if that is true, why didn’t the pipeline leak" earlier?

Frank G. Adams, president of Houston-based Interface Consulting International, said in an email that the slight bow in the line displayed in one video “doesn’t necessarily look like anchor damage.”

When a pipeline is hit by an anchor or other heavy object “that typically results in physical damage that may lead to a fracture,” he said.

Reports of a possible spill off Huntington Beach were first coming out Friday evening but the leak wasn't discovered until Saturday morning. While the size of the spill isn't known, the Coast Guard on Thursday slightly revised the parameters of the estimates to at least about 25,000 gallons (95,000 liters) and no more than 132,000 gallons (500,000 liters).

The Coast Guard said about 5,500 gallons (20,819 liters) of crude have been recovered from the ocean. The oil has spread southeast along the coast with reports of small amounts coming ashore in San Diego County, some 50 miles (80.47 kilometers) from the original site.

Local health officials said Friday that air samples from areas where oil potentially spread are within background levels — in other words, similar to air quality on a typical day — and below California health standards for the pollutants that were measured.

So far the impact on wildfire has been minimal — 10 dead birds and another 25 recovered alive and treated — but environmentalists caution the long-term impacts could be much greater. As cleanup continued on the shore, some beaches in Laguna Beach reopened Friday, though the public still can't go in the water.

Key questions remain: Could the line have been hit days, weeks or even months before the leak started? What ship is responsible? And if a ship anchor is not the culprit, what else could it be?

Investigators also are trying to determine what happened in the crucial early hours after reports of a possible oil spill first came in.

The narrow gash seen in one video could explain why signs of an oil slick were seen Friday night, but the spill eluded detection by the pipeline operator for more than 12 hours.

“My experience suggests this would be a darned hard leak to remotely determine quickly,” said Richard Kuprewicz, a private pipeline accident investigator and consultant. “An opening of this type, on a 17-mile-long (27-kilometer) underwater pipe is very hard to spot by remote indications. These crack-type releases are lower rate and can go for quite a while.”

When pipes experience a catastrophic failure, the breach typically is much bigger, what’s referred to in the industry as a “fish mouth” rupture because it gapes wide like the mouth of a fish, he said.

Amplify Energy, a Houston-based company that owns and operates three offshore oil platforms and the pipeline south of Los Angeles, said it didn’t know there had been a spill until its workers detected an oil sheen on the water Saturday at 8:09 a.m.

The Coast Guard on Thursday said it is investigating the incident with other agencies as a “major marine casualty” due to the potential involvement of a vessel and damages exceeding $500,000. It said they will determine if criminal charges, civil penalties or new laws or regulations are needed.

The leak occurred about 5 miles (8 kilometers) offshore at a depth of about 98 feet (30 meters), investigators said. A 4,000-foot (1,219-meter) section of the pipeline was dislodged 105 feet (32 meters), bent back like the string on a bow, Amplify’s CEO Martyn Willsher has said.

Jonathan Stewart, a professor of civil and environmental engineering at the University of California, Los Angeles, said moving a large section of pipe that far would have caused “bending deformations” – tension on the side that was stretched into a semicircle, with compression on the other, as it was bent inward, Stewart said.

It’s possible such pressure alone could result in a break, though Stewart said there is too little information to make a conclusion about the cause. It's possible a sharp section of anchor could pierce the pipeline but “you could still have damage just from the bending.”

“Because it’s pulling on the pipe, you create these bending stresses in the pipe, which could eventually become large enough that they rupture it,” he said.

Questions also remain about when the oil company knew it had a problem and a potential delay in reporting the spill.

A foreign ship anchored in the waters off Huntington Beach reported to the Coast Guard that it saw a sheen longer than 2 miles (3 kilometers) just after 6 p.m. on Oct. 1, and that evening a satellite image from the European Space Agency also indicated a likely oil slick, which was reported to the Coast Guard at 2:06 a.m. Saturday, after being reviewed by a National Oceanic and Atmospheric Administration analyst.

Federal pipeline safety regulators have put the time of the incident at 2:30 a.m. Saturday but say the company didn't shut down the pipeline until 6:01 a.m. — more than three hours after a low pressure alarm had gone off indicating a possible problem — and didn't report the leak to the Coast Guard until 9:07 a.m. Federal and state rules require immediate notification of spills.

Amplify said the line already had been shut down by 6 a.m., then restarted for five minutes for a “meter reading” and again shut down. A meter reading shows how much oil is flowing into and out of the line. The company could have been using that information to confirm if the pressure-change alarm was set off because the line was leaking, said Kuprewicz and Ramanan Krishnamoorti, a professor of petroleum engineering at the University of Houston.

The company said a boat discovered oil on the water at 8:09 a.m.

Copyright AP - Associated Press
Contact Us